MENGXin,CHENWei,CHENBai-xiao.Practice of Xiaoshan 4 000 t/d Centralized Sludge Incineration Project[J].China Water & Wastewater,2022,38(8):127-132.
蕭山4 000 t/d污泥集中焚燒處理項目實踐
- Title:
- Practice of Xiaoshan 4 000 t/d Centralized Sludge Incineration Project
- 關鍵詞:
- 污泥焚燒; 深度脫水; 循環流化床鍋爐
摘要:- 蕭山4 000 t/d污泥集中焚燒處理項目針對污水廠污泥處理難題，通過深度脫水與焚燒發電相結合的方式處理污泥。深度脫水工藝采用化學調理和機械壓濾的脫水方式，不同含水率的污泥通過一次壓濾脫水就能達到焚燒要求。脫水干化后的污泥含水率降至45%~50%，與質量比為10%的煤混合后，送入循環流化床鍋爐進行焚燒。與普通燃煤電廠摻燒污泥相比，本項目泥煤配比有重大突破，污泥焚燒量有很大的提高，入爐焚燒處理污泥達1 800 t/d（含水率45%）。污泥燃燒的余熱用于發電，實現了污泥能量轉化和凈能量輸出。煙氣處理系統配置石灰石-石膏濕法脫硫、靜電除塵、布袋除塵、低氮燃燒等技術措施，煙氣排放指標長期穩定優于歐盟2010排放標準。
Abstract:- In view of the difficult issues of sludge treatment in a wastewater treatment plant, Xiaoshan 4 000 t/d centralized sludge was treated by the combination of deep dewatering, incineration and power generation. Chemical conditioning and mechanical pressure filtration are adopted in the process of deep dewatering, and the sludge with various moistures can be dewatered to meet the requirement of incineration by the single dewatering process. After dewatering, the sludge moisture was reduced to 45%-50%. After mixing with coal of 10% weight, the sludge was sent to the circulating fluidized bed boiler for incineration. Compared with common coal-fueled power plants, the sludge-to-coal ratio is much higher, thus the sludge incineration capacity has been greatly improved as high as 1 800 t of sludge (moisture 45%) every day. The waste heat of sludge combustion is used for power generation, thus realizing energy conversion and net energy output. The flue gas treatment system is equipped with limestone-gypsum wet desulfurization, electrostatic dust removal, baghouse dust removal, low nitrogen combustion, and other technical measures, thus the gas emission stably outperforms the Directive of EU2010/75/EC in a long run.
相似文獻/References:
[1]郝曉地,于文波,時琛,等.污泥焚燒灰分磷回收潛力分析及其市場前景[J].中國給水排水,2021,37(4):5.
HAO Xiao-di,YU Wen-bo,SHI Chen,et al.Potential Analysis and Market Prospects of Phosphorus Recovery from the Bottom Ashes of Sludge Incineration[J].China Water & Wastewater,2021,37(8):5.
[2]應基光,林莉峰,邵欽.基于鼓泡流化床的污泥焚燒保護控制[J].中國給水排水,2021,37(10):133.
YING Ji-guang,LIN Li-feng,SHAO Qin.Protection Control of Sludge Incineration Based on Bubbling Fluidized Bed[J].China Water & Wastewater,2021,37(8):133.
[3]楊漢文,王建國,李沖,等.市政污泥干化焚燒技術應用工程案例[J].中國給水排水,2021,37(12):136.
YANG Han-wen,WANG Jian-guo,LI Chong,et al.Application Project of Municipal Sludge Drying and Incineration Technology[J].China Water & Wastewater,2021,37(8):136.
[4]趙林輝,林莉峰,朱運濤.大型污泥焚燒項目的污泥脫水運行優化研究[J].中國給水排水,2021,37(12):145.
ZHAO Lin-hui,LIN Li-feng,ZHU Yun-tao.Study on Operation Optimization of Sludge Dewatering in Large Scale Sludge Incineration Project[J].China Water & Wastewater,2021,37(8):145.
[5]段妮娜,譚學軍,張辰.污水處理廠污泥獨立焚燒的熱力計算方法解析[J].中國給水排水,2021,37(16):83.
DUAN Ni-na,TAN Xue-jun,ZHANG Chen.Analysis of Sewage Sludge Mono-incineration Thermodynamic Calculation Method in a Sewage Treatment Plant[J].China Water & Wastewater,2021,37(8):83.
[6]應基光,林莉峰,王麗花.白龍港污泥二期煙氣在線監測系統設計與調試[J].中國給水排水,2022,38(6):117.
YINGJi-guang,LIN Li-feng,WANG Li-hua.Design and Commissioning of CEMS for Bailonggang Phase Ⅱ Sludge Project[J].China Water & Wastewater,2022,38(8):117.
[7]朱運濤,林莉峰,趙林輝.污泥流化床焚燒煙氣污染物排放特性研究[J].中國給水排水,2022,38(11):115.
ZHUYun-tao,LINLi-feng,ZHAOLin-hui.Emission Characteristics of Pollutants in Flue Gas from Sludge Fluidized Bed Incineration Process[J].China Water & Wastewater,2022,38(8):115.
[8]汪蕓蕓,李夢瓊,林莉峰.鼓泡流化床污泥焚燒爐焚燒控制技術研究[J].中國給水排水,2022,38(18):42.
WANGYun-yun,LI Meng-qiong,LINLi-feng.Study on Incineration Control Technology of Sludge Bubbling Fluidized Bed Incinerator[J].China Water & Wastewater,2022,38(8):42.
